DIN wiring by the numbers...

[wayne petty]

this probably won't help a LOT of rodders right away.. but i bet it clears up some confusion when looking through a box of relays...  i wonder what this relay does...    look it up by terminal numbers...   might help figure out what it does and what voltage or signal should be where

might also make it easy to use 87 VW cabriolet fuel pump relays to control the electric fuel pumps in rods...  so the fuel pump relay is triggered by the pulsing negative side of the coil circuit also...  to keep it active.....

just printing the list below... and taping it inside a cabinet in the garage will be a life saver at some time in the future for the lucky few...

http://www.motor.com/magazine/pdfs/042003_07.pdf  





1 . . . . . . . . . . .Ignition Coil, Distributor
Low-Tension Circuit
Ignition Distributor With Two Insulated Circuits
1a . . . . . . . . . .to Ignition Point Set I
1b . . . . . . . . . .to Ignition Point Set II
Ignition Coil, Distributor
4 . . . . . . . . . . . High-Tension Circuit
Ignition Distributor With Two Insulated Circuits
4a . . . . . . . . . .Terminal 4, from Coil I
4b . . . . . . . . . .Terminal 4, from Coil II
15 . . . . . . . . . .Switch-Controlled Positive Downstream from Battery
(from Ignition Switch)
15a . . . . . . . . .In-Line Resistor Terminal Leading to Coil & Starter
Glow-Plug Switch
17 . . . . . . . . . .Start
19 . . . . . . . . . .Preglow
30 . . . . . . . . . .Line from Battery Positive Terminal (Direct)
31 . . . . . . . . . .Return Line from Battery Negative Terminal
or Ground (Direct)
31b . . . . . . . . .Return Line to Battery Negative Terminal or Ground Via
Switch or Relay (Switch-Controlled Ground)
Electric Motors
32 . . . . . . . . . .Return Line*
33 . . . . . . . . . .Main Connection*
33a . . . . . . . . .Self-Parking Switch-Off
33b . . . . . . . . .Shunt Field
33f . . . . . . . . .for Reduced-RPM Operation, Speed 2
33g . . . . . . . . .for Reduced-RPM Operation, Speed 3
33h . . . . . . . . .for Reduced-RPM Operation, Speed 4
33L . . . . . . . . .Rotation to Left (Counterclockwise)
33R . . . . . . . . .Rotation to Right (Clockwise)
*Polarity Reversal of 32/32 Possible
Starter
45 . . . . . . . . . .Separate Starter Relay, Output: Starter;
Input: Primary Current
Flasher Relay (Pulse Generator)
51 . . . . . . . . . .Input
49a . . . . . . . . .Output
49b . . . . . . . . .Output to Second Flasher Relay
49c . . . . . . . . .Output to Third Flasher Relay
Battery Switching Relay
50a . . . . . . . . .Output for Starter Control
Start-Locking Relay
50e . . . . . . . . .Input
50f . . . . . . . . .Output
Start-Repeating Relay
50g . . . . . . . . .Input
50h . . . . . . . . .Output
AC Generator (Alternator)
51 . . . . . . . . . .DC Voltage at Rectifier
51e . . . . . . . . .DC Voltage at Rectifier with Choke Coil
for Daylight Operation
Starter
52 . . . . . . . . . .Starter Control (Direct)
53 . . . . . . . . . .Wiper Motor, Input (+)
53a . . . . . . . . .Wiper (+), End Position
53b . . . . . . . . .Wiper (Shunt Winding)
53c . . . . . . . . .Electric Windshield Washer Pump
53e . . . . . . . . .Wiper (Brake Winding)
53i . . . . . . . . .Wiper Motor with Permanent Magnet & Third Brush
(for Higher Speed)
55 . . . . . . . . . .Front Fog Lamp
56 . . . . . . . . . .Headlights
56a . . . . . . . . .High Beam with Indicator Lamp
56b . . . . . . . . .Low Beam
56d . . . . . . . . .Headlight Flasher Contact
57 . . . . . . . . . .Parking Lamps (in some export markets)
57a . . . . . . . . .Parking Lamps
57L . . . . . . . . .Parking Lamps, Left
57R . . . . . . . . .Parking Lamps, Right
WIRING TERMINAL DESIGNATIONS
Terminal Definition Terminal Definition

58 . . . . . . . . . .Side-Marker Lamps, Taillamps, License Plate
& Instrument Illumination
58d . . . . . . . . .Rheostatic Instrument Illumination, Tail- & Side-Marker Lamps
58L . . . . . . . . .Left
58R . . . . . . . . .Right, License Plate Lamps
AC Generator (Alternator)
(Magneto Generator)
59 . . . . . . . . . .AC Voltage Output, Rectifier Input
59a . . . . . . . . .Charging-Armature Output
59b . . . . . . . . .Taillamp Armature, Output
59c . . . . . . . . .Stop-Lamp Armature, Output
61 . . . . . . . . . .Charge Indicator Lamp
Tone-Sequence Controller
71 . . . . . . . . . .Input
71a . . . . . . . . .Output to Horns I & II (Bass)
71b . . . . . . . . .Output to Horns 1 & 2 (Treble)
75 . . . . . . . . . .Radio, Cigarette Lighter
76 . . . . . . . . . .Speakers
77 . . . . . . . . . .Door Valve Control
Switches, Normally Closed (NC) Contacts & Changeover Contacts
81 . . . . . . . . . .Input
81a . . . . . . . . .First Output on NC-Contact Side
81b . . . . . . . . .Second Output on NC-Contact Side (NO Contacts)
82 . . . . . . . . . .Input
82a . . . . . . . . .First Output
82b . . . . . . . . .Second Output
82z . . . . . . . . .First Input
82y . . . . . . . . .Second Input
Multiple-Position Switch
83 . . . . . . . . . .Input
83a . . . . . . . . .Output (Pos. 1)
83b . . . . . . . . .Output (Pos. 2)
83L . . . . . . . . .Output (Left)
83R . . . . . . . . .Output (Right)
Current Relay
84 . . . . . . . . . .Input: Actuator & Relay Contacts
84a . . . . . . . . .Output: Actuators
84b . . . . . . . . .Output: Relay Contacts
Switching Relay
85 . . . . . . . . . .Output: Actuator (Negative Winding End or Ground)
Input: Actuator
86 . . . . . . . . . .Start of Winding
86a . . . . . . . . .Start of Winding or First Winding Coil
86b . . . . . . . . .Winding Tap or Second Winding Coil
Normally Closed (NC) Relay Contact & Changeover Contacts
87 . . . . . . . . . .Input
87a . . . . . . . . .First Output (NC-Contact Side)
87b . . . . . . . . .Second Output
87c . . . . . . . . .Third Output
87z . . . . . . . . .First Input
87y . . . . . . . . .Second Input
87x . . . . . . . . .Third Input
Normally Open (NO) Relay Contact
88 . . . . . . . . . .Input
88z . . . . . . . . .First Input
88y . . . . . . . . .Second Input
88x . . . . . . . . .Third Input
Normally Open (NO) Relay Contact & Changeover Contacts (NO Side)
88a . . . . . . . . .First Output
88b . . . . . . . . .Second Output
88c . . . . . . . . .Third Output
Generator/Alternator & Voltage Regulator
B  . . . . . . . . .Battery Positive Terminal
B  . . . . . . . . .Battery Negative Terminal
D  . . . . . . . . .Generator Positive Terminal
C  . . . . . . . . .Generator Negative Terminal
DF . . . . . . . . . .Generator Field Winding
DF1 . . . . . . . . .Generator Field Winding 1
DF2 . . . . . . . . .Generator Field Winding 2
Alternator
U, V, W . . . . . .Three-Phase Terminals
Turn Signals (Turn-Signal Flasher)
C . . . . . . . . . . .Indicator Lamp 1
C0 . . . . . . . . . .Main Terminal Connection for Indicator Lamp Not
Connected to Turn-Signal Flasher
C2 . . . . . . . . . .Indicator Lamp 2
L . . . . . . . . . . .Left-Side Turn Signals
R . . . . . . . . . . .Right-Side Turn Signals

[enjenjo]

That will come in real handy. Thanks Wayne.